|
LPG, CNG & LNG - General Info and Issues Share experiences and problems |
Information |
|
S60 Bi-Fuel 2003 - LPG issuesViews : 7279 Replies : 31Users Viewing This Thread : |
|
Thread Tools | Display Modes |
|
Oct 27th, 2016, 22:04 | #1 |
New Member
Last Online: Dec 29th, 2016 10:46
Join Date: Oct 2016
Location: Deeside
|
S60 Bi-Fuel 2003 - LPG issues
Hi. Can anyone help me with my 2003 Volvo S60 Bi-Fuel factory fitted LPG conversion and the current mileage 142k? I have a problem with LPG cutting off while driving on warm engine mainly (but not always). I have replaced: LPG filter as well as the LPG solenoid and nothing has changed since then. While driving on autogas the car begins to lose power (mainly warm engine) and, despite pressing the acceleration pedal the power goes down, until finally extinguished. It only allows me to drive when I immediately switch to petrol. I try to start the engine in LPG mode again and it starts but immediately revs go down and the engine goes off. I have to stop the car, switch off the engine and wait a few moments to start it in petrol mode and then I can switch on LPG again. Has anyone ever came across this issue?
I can only add a clue that it starts ok when the engine is cold and starts cutting off the LPG when becoming warm so it must have something to do with the temperature (but I'm not sure) whether it is going through reducer or somewhere else I don't know. Please help me if you can. Thanks in advance. |
Oct 28th, 2016, 08:55 | #2 |
Volvologist
Last Online: Dec 6th, 2023 11:13
Join Date: Aug 2008
Location: Bangor - Norn Iron
|
Mine would have occasionally done this if I had run out of gas and refilled, it would switch over and then after a minute of 2 get on as if it had run out of gas, switch off and restart and all way well again, but only done it very occasionally after refuelling.
The car shouldn't start on LPG unless warm, even then I think it starts on petrol and switches over instantly. Only common issues with them are the gas distributor and regulator. The regulator doesn't have a temp sender in it as far as I know, it take the temp off the engine sensor and changes over at 15 degrees iirc. It sounds very like a distributor problem for cutting out when driving if you take the loosing power out of the symptoms. It's a Necam system, so if you search that on ebay you should come up with a new distributor or they can be rebuilt by LPG specialists for around £60.
__________________
What's the matter with the car I'm driving? Can't you tell that it's out of style? Should I get a set of white wall tires? Are you gonna cruise the miracle mile? |
Oct 30th, 2016, 07:18 | #3 |
Classic P80 1999 BiFuel
Last Online: May 14th, 2024 12:59
Join Date: Aug 2012
Location: 48mph Middle Lane M4
|
£500 says you need a new stepper. It is NOT the dizzy per se. Common issue that Koltec/ Necam are well aware of but don't fix because it's good business.
Exchange from me at £180 + my tech support. Better than a new one for reasons I've explained many times. Leave Volvo dealers well alone. With the exception of one in Thirsk, leave most LPG specialist alone too. Me? I'd fix it myself. Very simple job. Read the threads on this. Then keep the dizzy clean/ fit a filter... Read the threads on this. If you are lucky you have the the cheaper Stepper motor and don't need my Volvo only, £180 version. £48 on ebay, and you're done. Read the threads on this. In fact... read the threads on this. Do this , and you'll soon be running fine. Yup - I'll double it, a £1000 says it's the stepper.
__________________
Bifuel V70 Classic 1999 [The Old Grumpy in the Corner, "When I was a lad... blah, bl**dy blah."] Last edited by CNGBiFuel; Oct 30th, 2016 at 07:32. |
Oct 30th, 2016, 23:45 | #4 |
New Member
Last Online: Dec 29th, 2016 10:46
Join Date: Oct 2016
Location: Deeside
|
|
Oct 31st, 2016, 08:11 | #5 |
Classic P80 1999 BiFuel
Last Online: May 14th, 2024 12:59
Join Date: Aug 2012
Location: 48mph Middle Lane M4
|
OK, I assume you have looked at your stepper. On some S60 & S80 you are able to use the £48.00 Stepper. Some early and some 2003 cars have this. The first 850 & V70 Bi-Fuels also ahd the cheap stepper. Have you checked? If so, you are unlucky.
You are left with the 'Volvo only' version. Identified by the flat top. It sounds like you know what they cost (usually 5-6 times the price). I know these systems well. If you buy an unmodded (used or new) stepper from Koltec/Necam, you will see the same issues in repeat maybe 25-50,000 miles later. If not kept clean or left unfiltered, much sooner. Do NOT buy the complete dizzy, unless you are lazy and don't want to clean it, or rich. Yours will only need cleaning. My steppers require you to pay a 'core' charge set deliberatly high to be sure I get your old stepepr back to allow me to recondition and fix the Triac that ails these. You also get my tech support (very useful when it all goes awry) and a guarantee that should my diagnosis and info be wrong, your money less couriers, is returned. You will not get this last point with other suppliers because they are 'box-shifters' only. My background is 35 years in electronics. If you blow a stepper I can usually repair quickly and easily. I am sure I knwo more about the Necam system that anyone in the world outside of Necam. LPG specialists just mindlessly swap modules and components until something works. [Where might you think I get my supply of so called 'no good' parts from?] For added compliation, (read expense) the £48 stepper is not matched with the ECM in your car. The stepper motor is at the route of most of the bad-mouthing of what is otherwise a very simple system that works well, gaining a poor reputation undeserved. Clean it, correct the stepper and all works.
__________________
Bifuel V70 Classic 1999 [The Old Grumpy in the Corner, "When I was a lad... blah, bl**dy blah."] Last edited by CNGBiFuel; Oct 31st, 2016 at 08:35. |
Oct 31st, 2016, 12:01 | #6 |
New Member
Last Online: Dec 29th, 2016 10:46
Join Date: Oct 2016
Location: Deeside
|
I don't know how to get access to the stepper/distributor. It's in really inaccessible place (bottom between engine and cooler) and has no marks to identify.
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|