1997, S40, 1.8i, fuel filter

[EDW2000]

Can someone tell me how often the fuel filter needs changing, where it is and do you need any special tools to change it?

Also is there a cabin filter to change?

thanks.

[hutch63]

Not an expert but this would come in your FULL SERVICE. time frame.

i would say at least once a year.
if you have the quinton hazell part number i may have one here going cheap.

as for special tools yes you may well have to have one, so double check before you start .

regards

[druid]

The fuel filter will be found on the rear left just in front of the wheel. The is or should be a plastic flap over it. No special tools needed as there is a plastic quick release that might give trouble. Mine has a jubilee clip over it now for added safety.

[EDW2000]

Originally Posted by druid

The fuel filter will be found on the rear left just in front of the wheel. The is or should be a plastic flap over it. No special tools needed as there is a plastic quick release that might give trouble. Mine has a jubilee clip over it now for added safety.

thanks,is there a cabin filter?

Maybe I need a Haynes manual.

[druid]

There might not be on yours, easy to check though, pull the bottom carpet out of the front left footwell - thats the bit the passengers toes point at - if you have one you will see a clip about 6 inches long that hols the pollen filter.

[magnuz]

Haynes manual says every 80,000 miles or 8 years for fuel filter on petrol engines.
Have a look at it anyway as they sometimes get quite rusty & can then start to leak.
Although they have quick release pipe connectors they can sometimes be rather stubborn to get them to release as they should !
Be aware that there may be some pressure in the pipes & a small amount of fuel may squirt out when you release the pipes, have a container ready to catch the fuel, & wear goggles if laying under the car anywhere near to it !

[EDW2000]

Originally Posted by magnuz

Haynes manual says every 80,000 miles or 8 years for fuel filter on petrol engines.
Have a look at it anyway as they sometimes get quite rusty & can then start to leak.
Although they have quick release pipe connectors they can sometimes be rather stubborn to get them to release as they should !
Be aware that there may be some pressure in the pipes & a small amount of fuel may squirt out when you release the pipes, have a container ready to catch the fuel, & wear goggles if laying under the car anywhere near to it !

I think you remove the fuel pump fuse then start the engine till it cuts out so the filter and lines are empty. I will phone Volvo and check if you need a special tool for the removal. I will try and open old filter and get a photo for the forum.

[ITSv40]

Originally Posted by EDW2000

thanks,is there a cabin filter?

Maybe I need a Haynes manual.

No pollen filter on a '97.