|
S80 '98-'06 / S60 '00-'09 / V70 & XC70 '00-'07 General Forum for the P2-platform S60 / V70 / XC70 / S80 models |
Information |
|
Intermittent severe steering wheel vibrationViews : 794 Replies : 20Users Viewing This Thread : |
|
Thread Tools | Display Modes |
|
May 8th, 2024, 09:02 | #1 |
Master Member
Last Online: May 23rd, 2024 17:44
Join Date: Nov 2001
Location: Evesham
|
Intermittent severe steering wheel vibration
Volvo V70, 2002, manual, petrol, 180k miles
I have a very intermittent severe steering wheel vibration / shimmy / shake / wobble. I have a 120mile commute (60 miles each way), mostly on the motorway. Twice now at about halfway back a vibration builds up in the steering. It stays for about five minutes then gradually fades away (without any additional steering input or brake/throttle input). What on earth could be causing this? I can imagine many reasons but none that would be so intermittent. Any advice would be much appreciated. Here are some further details. Seems to be there from 50 to 60 mph while driving in a straight line. Not linked with a particular road speed, engine speed (no change on disengaging clutch), braking, steering direction, or road surface. Wheel nuts are not loose. Tires and rims look fine. Power steering reservoir full (I changed the fluid last year). Brakes are not getting hot. Handbrake is not stuck on. No ABS fault (I don’t have traction control). I hear nothing when on full steering lock. Car does not pull either way, including under braking. Suspension has all Volvo components. I have replaced drop links about four years back. Lower control arms also replaced but that was around 10 years ago. This does not feel like wheel imbalance. When not there steering feels fine, and car drives well. I’ll get the front wheels off at the weekend to see if I can spot anything. I’ll also switch the front wheels to the rear while I’m at it. |
May 8th, 2024, 15:26 | #2 |
Premier Member
Last Online: Yesterday 23:36
Join Date: Mar 2017
Location: Manchester
|
after 10 years its possible that the lower arms bushes have failed again check for any tearing on the round part as this is where they fail most often. dose the vibration start at the same part of repeat journeys it may be triggered by road surface changes.
|
The Following User Says Thank You to Simmy For This Useful Post: |
May 8th, 2024, 16:24 | #3 |
Master Member
Last Online: May 23rd, 2024 17:44
Join Date: Nov 2001
Location: Evesham
|
Thanks for that. It occurred about 20 miles apart on the M5 on two different journeys (only once per journey), so not the same place.
I think / hope I've discovered what it is. The righthand front disc is blue, indicating overheating. This is weird as when I got home all wheels were cool to the touch (and did not smell hot – as I’ve experienced in the past), but that was 30 miles later on. So, I'm thinking that the caliper must randomly partly be jamming on during light braking, causing this horrible vibration, and then releasing all at motorway speeds. I am guessing this could be the caliper itself or the flexible brake hose collapsing inside (which are all original – front and back). Anyway, I'll get the caliper off at the weekend. I know disconnecting old and corroded brake hoses can be a nightmare, so I'm not looking forward to that. |
May 8th, 2024, 16:41 | #4 |
Premier Member
Last Online: Yesterday 23:36
Join Date: Mar 2017
Location: Manchester
|
check for any indentations where the pads sit on the caliper carrier as these can cause the pads to stick hoses usually come loose easily use a good brake line spanner to avoid any rounding of the nut on the line.you will more than likely need new discs if damaged by excessive heat.
|
May 10th, 2024, 03:23 | #6 |
Premier Member
Last Online: Yesterday 21:02
Join Date: Feb 2009
Location: Hackensack
|
I had a 2002 petrol of about the same mileage, and I can report that on a gentle, downhill curve to the left on a state road, an anachronistic term for motorway, I experienced a wobble which rocked my world.
Visions of shot inner tie rods...outer tie rod ends...control arm bushings....and other fancy stuff, danced through my head. All are legit concerns. However, this deep shake didn't appear otherwise. It was easy to compartmentalize...aka ignore. In the meantime, my fronts wore down and were replaced. The brand and model wouldn't apply to you as you're 'on the other side', but the phenomenon disappeared. FYI: The new "miracle tires" were Cooper CS-4's; again, N/A to you. So, I tell you; put on your x-ray glasses and peer into your tires. It wouldn't be the first time on Planet Earth that bashed/worn tyers caused zizzbo. Also, worn dampers are the pits. I refreshed mine before "180k miles" and I'd recommend that too. Your car is at the age for some 'broad brush work'. |
May 10th, 2024, 15:33 | #7 | |
Experienced Member
Last Online: Yesterday 22:39
Join Date: Jun 2007
Location: L/H side
|
Quote:
__________________
My comments are only based on my opinions and vast experience . |
|
The Following 3 Users Say Thank You to Clan For This Useful Post: |
May 10th, 2024, 16:47 | #8 |
Master Member
Last Online: May 23rd, 2024 17:44
Join Date: Nov 2001
Location: Evesham
|
I did wonder about that as a possibility but it seems far too violent for wheel imbalance (and too infrequent). I've got a new caliper and two new front hoses on order.
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|