|
850 / S70 & V70 '96-'99 / C70 '97-'05 General Forum for the 850 and P80-platform 70-series models |
Information |
|
Electronic Throttle System (Gulp!)Views : 620 Replies : 9Users Viewing This Thread : |
|
Thread Tools | Display Modes |
Jan 7th, 2019, 17:12 | #1 |
Ovlovnut
|
Electronic Throttle System (Gulp!)
99' T5SE Auto. 129000 miles.
Set off out today running fine. After about 3-4 miles went for a kickdown overtake & went into 'bog down' very rough and no omph.Then the ETS lamp came on. Overtake aborted & I limped to a nearby oppo's place. Once there I disconnected the battery (rightly or wrongly?) . Left it 20 or minutes and then fired up. It died. 2nd attempt lumpy then died. 3rd attempt fired, I kept it running by giving it some gas & it settled to an idle. ETS lamp now off. Decided to head for home, it ran quite happily at 50mph (so not in limp?). We got home. Tried revving it gently, runs upto 3k then began to splutter & pop. As we were going out, set of the ph2. Just tried my code readers. Cheap Autel shows no codes pending or otherwise . Then tried my OBDsxLInk connected to my laptop & again no codes, pending or otherwise. The car is now cold & I tried to start. 1st fire and died. Second just span on starter, no start. Dark now so 'play' stopped. I suspect the dreaded Electronic Throttle Module, which I think can mean 'end game' Any suggestions?
__________________
2004 V70 2.4SE Auto 'The Welshmobile’ 2002 Laika Ecovip 400i ( Motorhome on an Iveco 2.8TD) http://www.gitessouthbrittany.com/ http://moncopainmonchien.jimdo.com/ |
Jan 8th, 2019, 00:08 | #2 |
Premier Member
Last Online: Apr 21st, 2024 15:36
Join Date: Dec 2002
Location: Co. Limerick, Ireland
|
It's the ghosts of Gent, Paul...
Some options for you to consider... ECU Testing - ARD Tuning Repair Kit - BBA Reman ...before you condemn an otherwise perfectly good motor. Out of interest...have you changed the Engine Coolant Temperature Sensor in your ownership? If not it's a damn sight cheaper than a new/refurbed ETM. A thorough clean of the throttle body may also help.
__________________
Liam... '96 854 TDI SE, '99 V70 2.5D S, '05 C70 2.0T Collection, '05 S80 2.0T SE, '15 V70 D4 SE Lux Nav. |
The Following User Says Thank You to Baffler For This Useful Post: |
Jan 8th, 2019, 07:58 | #3 |
Ovlovnut
|
Thanks Liam. That's given me a good heads up.
No I haven't changed the temp sensor......yet.
__________________
2004 V70 2.4SE Auto 'The Welshmobile’ 2002 Laika Ecovip 400i ( Motorhome on an Iveco 2.8TD) http://www.gitessouthbrittany.com/ http://moncopainmonchien.jimdo.com/ |
Jan 8th, 2019, 09:24 | #4 |
Ovlovnut
|
Woohoo!
My panic maybe over. Was thinking during the night, on my old 480 tub, the turbo pipe used to blow off on a regular basis. Causing same issues as the T5 has.
Had a look just now & see what I found. Pretty sure this would explain the lack of codes too? Fingers crossed.
__________________
2004 V70 2.4SE Auto 'The Welshmobile’ 2002 Laika Ecovip 400i ( Motorhome on an Iveco 2.8TD) http://www.gitessouthbrittany.com/ http://moncopainmonchien.jimdo.com/ |
Jan 8th, 2019, 13:20 | #5 |
Ovlovnut
|
That was a broken (rusted through) jubilee clip. Nipped out to get a new one. Fitted it went for a blat, job done. What a lot of fuss over nowt
__________________
2004 V70 2.4SE Auto 'The Welshmobile’ 2002 Laika Ecovip 400i ( Motorhome on an Iveco 2.8TD) http://www.gitessouthbrittany.com/ http://moncopainmonchien.jimdo.com/ |
Jan 9th, 2019, 10:51 | #6 |
Premier Member
Last Online: Today 09:20
Join Date: Sep 2017
Location: STANDISH LANCASHIRE
|
If you have a rusted Jubilee clip this bad then it is worth checking others- particularly the water hoses that are out of normal view.
Bob |
The Following User Says Thank You to Bob Meadows For This Useful Post: |
Jan 10th, 2019, 22:29 | #7 |
Premier Member
Last Online: Apr 21st, 2024 15:36
Join Date: Dec 2002
Location: Co. Limerick, Ireland
|
Excellent! Nice handy fix
I agree with Bob in that you should check for any other potential failures such as the lower radiator and intercooler hose clips.
__________________
Liam... '96 854 TDI SE, '99 V70 2.5D S, '05 C70 2.0T Collection, '05 S80 2.0T SE, '15 V70 D4 SE Lux Nav. |
The Following User Says Thank You to Baffler For This Useful Post: |
Jan 10th, 2019, 22:43 | #8 |
Ovlovnut
|
Good shout Bob and Liam, will do as I am told.
__________________
2004 V70 2.4SE Auto 'The Welshmobile’ 2002 Laika Ecovip 400i ( Motorhome on an Iveco 2.8TD) http://www.gitessouthbrittany.com/ http://moncopainmonchien.jimdo.com/ |
Jan 14th, 2019, 21:43 | #9 |
C70 T5
Last Online: Mar 23rd, 2022 21:00
Join Date: Sep 2006
Location: Midlands
|
What is the the part that is at fault in the picture?
Looks like its near the rad to me. Good to hear its sorted!
__________________
2000 C70 T5 GT Coupe 1998 S70R / 1995 Toyota Supra Twin Turbo 2007 Mercedes CLS 320 CDI / 2011 Mercedes S350 Bluetec 2007 Suzuki GSXR-1000 |
Jan 14th, 2019, 21:51 | #10 |
Ovlovnut
|
Right down the bottom of the pic, below my maglite you should be able to see a hose detached?
__________________
2004 V70 2.4SE Auto 'The Welshmobile’ 2002 Laika Ecovip 400i ( Motorhome on an Iveco 2.8TD) http://www.gitessouthbrittany.com/ http://moncopainmonchien.jimdo.com/ |
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|