|
Diesel Engines A forum dedicated to diesel engines fitted to Volvo cars. See the first post in this forum for a list of the diesel engines. |
Information |
|
Burning oil and DPF filter clogging.Views : 8860 Replies : 22Users Viewing This Thread : |
|
Thread Tools | Display Modes |
Apr 1st, 2014, 20:47 | #1 |
New Member
Last Online: May 15th, 2014 23:46
Join Date: Apr 2014
Location: Leeds
|
Burning oil and DPF filter clogging.
I have 2008 V70 D5 90,000 miles. Approximately 8 months ago. Noted increase in fuel and oil consumption. DPF regen light started to come on. Took it to garage and they replaced swirl flaps. Since then DPF light came on saying Soot filt full and limp home mode. Garage forced regen and replaced a sensor on DPF. Since then oil consumption has increased and I have now noticed engine is burning oil. Can only see blue smoke in large bursts normally when accelerating having slowed down for a hazard then accelerating away. Soot filter light only comes on after long journeys usually followed by limp home mode but often resets itself once car has been stood overnight. Garage now unsure if its an engine fault or turbo fault. Has anybody had any similar experiences or can help. Everbody says these faults are uncommon with this engine.
Last edited by jezthebear; Apr 1st, 2014 at 20:50. |
Apr 1st, 2014, 21:51 | #2 |
Member
Last Online: Nov 15th, 2017 16:44
Join Date: Dec 2011
Location: Dorking/Peterborough
|
Forgot about these guys in the garage you were visiting. Take it to first Volvo authorised dealer and let them plug it in their computers to see what's wrong! All these replacements must have been unnecessary expense!
Good luck, Yodan |
Apr 1st, 2014, 23:00 | #3 |
New Member
Last Online: May 15th, 2014 23:46
Join Date: Apr 2014
Location: Leeds
|
Thanks Yodan but I cannot trust dealers. Last time a took to the main dealer they told me my brakes were faulty. They wanted a thousand pound to fix them then said there was nothing wrong when they realised car was under warranty. They then argued amonst themselves over it. Finally replaced the part. They then damaged my car and tried to cover it up.
|
Apr 2nd, 2014, 00:53 | #4 |
New Member
Last Online: Mar 30th, 2015 23:49
Join Date: Mar 2013
Location: Cleckheaton
|
Hi mate, have you tried Clive Brooks in Bradford? My personal experience is they're a dam sight better than your local dealer. Don't write off all main dealers because of 1 bad experience. Just for record I have a 2005 V70 2.4 d with 104000 miles and haven't had the same problem. Good luck with sorting it out. Dave
|
Apr 2nd, 2014, 09:29 | #5 | |
Member
Last Online: Nov 15th, 2017 16:44
Join Date: Dec 2011
Location: Dorking/Peterborough
|
Quote:
|
|
Apr 2nd, 2014, 12:24 | #6 | |
Premier Member
Last Online: May 2nd, 2018 08:14
Join Date: Sep 2011
Location: DownSouth
|
Quote:
Wild guess, but it does sound like the turbo might be leaking oil into the exhaust. That will block the CAT and DPF in the long term. If you are not using a low Zinc (C2 or 3) engine oil it will block the DPF fairly quickly and if a regen or two fails, then it's new DPF time. A Regen can't clean out oil ash, as it does not burn. The other possible cause might be gummed up injectors causing diesel contamination of the engine oil (A blocked DPF will also do that) and Carbon in the DPF. High cylinder head temps from a dodgy thermostat, water pump or oil sludge blocking the oil pump intake will also cause white or grey smoke. If you have been doing more than 10K mile plus OCI's, it might even be oil getting past the rings. How much oil is it burning?
__________________
2003 V40 1.9TD Mods: Scratches, bent bumpers, raised REAR mats & internal mud guards. SHELL ULTRA 5/40 & LIQUI MOLY CERATEC. Everyone should DYOR (Do Your Own Research) Last edited by skyship007; Apr 2nd, 2014 at 12:31. |
|
Apr 2nd, 2014, 20:04 | #7 |
Master Member
Last Online: Sep 29th, 2022 20:46
Join Date: May 2007
Location: Leeds
|
You could try taking it to P&R on Kirkstall road, not the cheapest indie going but pretty good and they have all the gear to read the codes.
If you prefer a full stealer then Clive Brooks on canal road in Bradford is one of the better ones around here. Also cheap for spares if you go via their ebay shop. The stealer who tried to screw you and then argued amongst themselves - Harratts Leeds by any chance They're the biggest set of t*@^$s I've ever had the misfortune to deal with. The Wakefield branch has a better manager but I'd only use Harratts again as a last last last last last last resort! Actually I'd scrap the car before I went back to them!
__________________
Defected to BMW. 335d xdrive. |
Apr 2nd, 2014, 20:30 | #8 |
VOC Member
Last Online: Today 14:28
Join Date: Feb 2013
Location: North Yorkshire
|
might be a bit of a trek for you but mill Volvo Knaresborough are also very good more than helpful in my experience with them
__________________
Previous -03 S40, 04 V70 D5, 04 V70 D5 Sport, 05 V50, 07 S60 D5, 09 V70 D5 R design, 12 XC60 DrivE, 15 V60 D3 Current- 05 XC90 D5 Exec, 12 XC70 D4 AWD Se Lux, 14 S80 D3 Se Lux |
The Following User Says Thank You to GrahamBrown1 For This Useful Post: |
Apr 2nd, 2014, 22:47 | #9 |
New Member
Last Online: May 15th, 2014 23:46
Join Date: Apr 2014
Location: Leeds
|
Just towed my Caravan for about 60 miles travelled round for another 80 miles or so on a run and it used a litre.
|
Apr 2nd, 2014, 22:51 | #10 |
New Member
Last Online: May 15th, 2014 23:46
Join Date: Apr 2014
Location: Leeds
|
Spot on Harratts in Leeds. To be honest Wakefield werent much better. Asked them to diagnose a noise fault with previous car. Said it was alternator wanted hundreds of pounds to replace it. Took it back to Garage where i bought it not Volvo Garage and they said it was a drive belt bearing. which cost under £100.
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|