|
S80 '06-'16 / V70 & XC70 '07-'16 General Forum for the P3-platform S80 and 70-series models |
Information |
|
Euro 4 D5 rough running smoke AFTER running a few minutesViews : 668 Replies : 8Users Viewing This Thread : |
|
Thread Tools | Display Modes |
|
Dec 27th, 2021, 18:34 | #1 |
New Member
Last Online: Mar 5th, 2022 10:25
Join Date: Dec 2021
Location: Lanark
|
Euro 4 D5 rough running smoke AFTER running a few minutes
Afternoon all,
Bit of a strange one here Cars had loads of work First thought it was injectors so had a swap about and no change. Compression test, injector quantity etc all OK. Car starts fine from cold but after a few minutes it's like flicking a switch and the car starts running rough and smoking quite bad Turning the car off and re starting and it does the same thing again Car has egr blanked and dpf is gone as though this is what the issue was as oil level was rising and smelled of diesel. Also don't know if it's coincidence but has a decent oil leak at the rear of the engine near the timing belt which seems to run down to the lower engine mount. From reading a couple other threads there seems to be some discussion on a blocked oil separator and maybe a vacuum leak to the egr bypass valve? It feels like an electronic fault as like I say it runs great then it's like something turning off or on and it instantly starts running rough and smoking.... Pretty much the opposite of normal running faults which are from cold then disappear after a few minutes... If anyone has any ideas I'd be greatful. Many thanks Cossie7 Sorry originally posted in the V50 section but due to it been a D5 I think it's probably better suited here. |
Dec 27th, 2021, 20:26 | #2 |
Junior Member
Last Online: Jan 1st, 2024 01:54
Join Date: Dec 2021
Location: Stafford
|
Coming from the world of VAG it could be a temperature sensor issue- Mk2 drivers will be very familiar with blue sensor issues.
Have you noticed a slump in your fuel economy? Could be that the ECU is registering a permanently cold engine state and over-fuelling/ running too rich. |
Dec 27th, 2021, 20:51 | #3 |
New Member
Last Online: Mar 5th, 2022 10:25
Join Date: Dec 2021
Location: Lanark
|
Hi, thanks for the reply, looking at live data there is nothing out the ordinary...
I'll have to have another look as now you've said it I can't remember if there is coolant temp and cylinder head coolant temp readings... Mind you thinking about it, if I turn it on and off after times it will sometimes behave and if it does behave and gets hot it will drive fine and not do it until its been left for a while. I know where your coming from though had a few cars that were undriveable when the cts was acting itself. Cheers |
The Following User Says Thank You to Cossie7 For This Useful Post: |
Dec 28th, 2021, 13:37 | #4 |
New Member
Last Online: Mar 5th, 2022 10:25
Join Date: Dec 2021
Location: Lanark
|
|
Dec 28th, 2021, 13:38 | #5 |
New Member
Last Online: Mar 5th, 2022 10:25
Join Date: Dec 2021
Location: Lanark
|
https://youtu.be/U8SKTeeJtiw
Video 2- car running fine then you hear it change and seems to drop a cylinder and roll smoke screen |
Dec 28th, 2021, 15:52 | #6 |
Junior Member
Last Online: Jan 1st, 2024 01:54
Join Date: Dec 2021
Location: Stafford
|
MAF could be a good shout, is there any change in the data when the noise varies?
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|