|
140/164 Series General Forum for the Volvo 140 and 164 cars |
Information |
|
LPG ConversionViews : 1015 Replies : 4Users Viewing This Thread : |
|
Thread Tools | Display Modes |
Sep 6th, 2017, 10:43 | #1 |
Master Member
Last Online: Apr 30th, 2023 15:34
Join Date: Dec 2011
Location: Bristol
|
LPG Conversion
Hi All
I am very seriously looking to install LPG into my May 1970 144 Auto. Currently a single Stromberg (with the yellow coffin shaped temp compensator) with a recently fitted unleaded cylinder head by KG Tunning (bought from Brookhouse), 123 ignition and no alteration to the camshaft. I’m not looking for performance, simply cost saving. Currently spending approximately £200 a month on fuel, so looking to roughly halve that figure. I have a few questions that I hope some of you may be able to answer. Also just after general comments from anyone who’s had this work done. 1. Do you need to get this done by a licensed installer? 2. Does it count as a modification, as far as insurance is concerned? If so, would it add to my premium? 3. Is ‘duel fuel’ the norm? I’ve heard that they prefer to cold start with unleaded and then switch to LPG once warmed up. 4. Cost? 5. I understand a hole will need to be inserted into the panels for the hose and a switch at the dash? Any other major holes or cutting? 6. I’m near Bristol – any recommended installers? Thanks all
__________________
just the one - 1970 144DL Auto |
Sep 6th, 2017, 15:05 | #2 |
Trader Volvo in my veins
Last Online: Yesterday 18:07
Join Date: Dec 2004
Location: Anglesey
|
In the UK DIY installing is allowed. Your insurance may require a inspection certificate or uklpg registration.
You must notify your insurance but it is not considered a modification. Dual fuel is only normally used on diesel engines. Petrol engines are bi-fuel allowing you to switch between fuels. With a carb engine you will normally start on LPG and just let the engine warm a little before pulling away. Cost for a fitted conversion allow between £800 and £1200 For the filler I normally mount it under the rear bumper so you can fill from either side and save drilling the wing. Switch on late 140 I fit it to one of the switch blanks or on early cars into the center console. I have hidden one switch in the ash tray! As to installers I suggest speak to a few and pay them a visit. |
The Following User Says Thank You to classicswede For This Useful Post: |
Sep 9th, 2017, 20:39 | #3 |
Too many cats
Last Online: Aug 24th, 2023 09:02
Join Date: Aug 2011
Location: Birmingham
|
Complete
I have a very early 164 with LPG. Drove it to current resting place a while ago. I'll sell you the whole car, it's actually not too bad and worth putting back on the road
__________________
Mark |
Sep 10th, 2017, 21:33 | #4 |
Master Member
Last Online: Apr 30th, 2023 15:34
Join Date: Dec 2011
Location: Bristol
|
What's the bodywork like and those all important panels?
__________________
just the one - 1970 144DL Auto |
Sep 11th, 2017, 19:11 | #5 |
Too many cats
Last Online: Aug 24th, 2023 09:02
Join Date: Aug 2011
Location: Birmingham
|
164
Better than you'd expect. It's so early there are no headrests, sunroof or power steering! Sills, arches reasonable. Wings and nose very good as I recall. I think the screen surround is good too. Dark green manual overdrive and it did all work. PM me and I'll give you a number to call. I believe it is among, if not the oldest around. 1968 G. I can't give it away because of the value of the bits but I'd like to see it be of use to someone.
__________________
Mark |
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|