|
S40 / V40 '96-'04 General Forum for the Volvo S40 and V40 (Classic) Series from 1995-2004. |
Information |
|
V40 1.9D 2001 Sensor ReadingsViews : 819 Replies : 3Users Viewing This Thread : |
|
Thread Tools | Display Modes |
Jun 16th, 2018, 22:01 | #1 |
New Member
Last Online: Nov 24th, 2022 10:38
Join Date: May 2018
Location: Belgrade
|
V40 1.9D 2001 Sensor Readings
Hello,
this is my first post to this forum. I red almost everything about problems with my model of car. I have V40 2001 1.9D 85KW car. I have power problem under 2500rpm. No vac leaks. I clean EGR valve last week it was clogged. There is leak on inlet manifold where shut off valve meets it. I will change gasket in few days with Renault one spare because of oil leak behind inlet. I tested some sensors today and I need to check reading that I have wrote. N75 resistance: 16.5 ohms MAF sensor signal to ground : on idle 2.3V and rising to 3.2V with rev up MAP sensor signal to ground: 1.9V on idle and rising to 2.7 with rev up Can someone check voltages and resistance on this and other sensors on their cars. I don't know what other fuel sensors are but there are three sensors on passenger side of engine: I guess this are camshaft, fuel pressure and fuel temp sensors. Can somebody explain usage and test procedures of sensors shown on attached picutre If someone can check resistance on his injector two leads. And if one can tell how to check IAT (intake air temp) sensor (resistance, voltage ...). My IAT sensor is one integrated in MAF sensor. Also, I want to test APP (accelerator pedal position sensor) - all readings of this potentiometers are wellcome. Vida reference: Thank you Sasa from Belgrade, Serbia Last edited by sasayu1983; Jun 16th, 2018 at 23:39. |
Jun 17th, 2018, 18:30 | #2 |
New Member
Last Online: Nov 24th, 2022 10:38
Join Date: May 2018
Location: Belgrade
|
Here are the names of sensors and my readings.
Can someone tell if position signal of EGR grows with revving because my stays at 1.15V |
Jun 18th, 2018, 09:52 | #3 |
Premier Member
Last Online: Nov 15th, 2022 21:34
Join Date: Apr 2010
Location: London / Essex
|
Not sure what the voltage of the EGR should be. It opens at specific times, when the engine is cold, so it warms ups faster with the reuse of some of the hot exhaust gases. So try measuring the voltage with a cold engine and see if it changes as it rises in temperature
__________________
Current car: 2002 S40 1.9D, 1992 240SE Nullius in Verba
|
Jun 19th, 2018, 16:57 | #4 |
Junior Member
Last Online: Jan 25th, 2021 18:49
Join Date: Jun 2018
Location: Bangor
|
Hi, I had exact same problem with my own v40d.
It would be flat and lacking power until over 2500rpm.I replaced the n75 valve as this is usually the fault with them, as fitted 100s of them at the Volvo dealer.It was slightly better,but not perfect. I plug my diagnostic in and read off codes and live data. The MAF reading air flow was very low and air temp was high.I disconnected MAF plug and road tested.The performance was better still. I fitted a new MAF and what a difference.It absolutely flies, even though it's had a 167bhp remap. |
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|