|
PV, 120 (Amazon), 1800 General Forum for the Volvo PV, 120 and 1800 cars |
Information |
|
best modificationViews : 9124 Replies : 44Users Viewing This Thread : |
|
Thread Tools | Display Modes |
Oct 28th, 2009, 10:01 | #11 |
Master Member
|
Regarding the roadhandling the beefier swaybar was a big plus, together with the Koni classic shocks. I like the Konis because you can adjust them to your liking. Together with PU bushings allround makes it stick to the road. In the summer the interior used to get really hot because of the exhaust and BW35. I used this stuff made from carbon fibers on the firewall and transmission tunnel. I also removed the first silencer under the passenger side floor.These mods reduced the heat a lot in the interior and even reduced the interior noise. Next mod would be a manual, probably a M46 or M47.
__________________
|
Oct 28th, 2009, 11:23 | #12 |
Master Member
Last Online: Oct 1st, 2023 14:39
Join Date: Dec 2004
Location: leics
|
The best mod I have done, which was free apart from time and a few M8 nuts and bolts, was moving the driving seat back by 6 inches. This gives me my preferred driving position, arms slightly bent from full extension, and removes that fear I have of my head hitting the steering wheel at high speed (not that i should worry as if that happened it would shortly be followed by my neck snapping as I don't have headrests!).
Heated rear screen is pretty good. Eleccy ignition for never having to worry about dwell angles again. Alternator for obvious reasons. I have just fitted 123 ignition which has improved the response and consistency of the spark no end (timing marks static rather than jumping around like a leprechaun). This is my second amazon and thus I want to get it right. The dizzy was an unknown, and probably high mileage so, in all, I thought the £260 delivered price for the 123 was good value. If your distributor is newish or known low mileage and has been looked after then I would just go for the petronix electronic ignition, which I had on my first amazon and was also excellent value. Remain a little unconvinced about PU bushes, bilsteins, and lowered springs. This has been discussed at length but I am sure the handling improvemnets need to be done in the correct order to get the most benefit. Things i want to do are fit the beefier antiroll bar, front only, get the geometry set up properly, wider tyres and wheels, without inducing bumpsteer. Headlight convo, sports exhaust and OD gearbox. Last edited by jimbo1593; Oct 28th, 2009 at 11:49. |
Oct 28th, 2009, 12:30 | #13 |
amazondean
Last Online: Apr 15th, 2024 12:19
Join Date: Oct 2004
Location: Nettleton Market Rasen
|
One upgrade that hasn't been mensioned is changing the fan motor for the early 6v because it spins twise as fast. I changed mine about 2 years ago and makes a huge difference in the winter. I know the amazon has a good heater but in the winter it's not that good but now it is. I have never had any problems with overheating of wires or blowing fuses either. I suspect one day the motor will burn out but then i will just put the original back in. I had to change the front cover of the blower unit for the early dome one but thats all thats needed to change.
Regarding the bushes, I'm afraid i dont agree with the polly bushes at all. My bushes were replaced many years ago by the previous owner for standard rubber and he used the car daily. Since i finished restoring it about three years ago the bushes are still in perfect condition and are a long way off needing replacing. infact i have never replaced a bush in any amazon to date and i have owned seven or eight at present. If the bushes are wearing out in the said year or so there must be other issues causing it, or a vested interest in polly bush conversions!!
__________________
There are only two things in life that is easy. One's lying down and the other is handing your credit card over. everything else has a degree of skill. Volvo 850 TDI, 850 TDI, 850 TDI Volvo V70 TDI, V70 TDI, Volvo V70 XC, (99) |
The Following User Says Thank You to amazondean For This Useful Post: |
Oct 28th, 2009, 21:58 | #14 | |
Trader Volvo in my veins
Last Online: Today 09:29
Join Date: Dec 2004
Location: Anglesey
|
Quote:
Witha ll that heat you would have expected valve / seat problems but even after over 100,000 miles on unleaded the head was in perfect shape. The amazon system is far to small for a B20 |
|
Oct 28th, 2009, 22:09 | #15 | |
Trader Volvo in my veins
Last Online: Today 09:29
Join Date: Dec 2004
Location: Anglesey
|
Quote:
PU bushes have lots of advantages over rubber bushes but only one disadvantage - normaly a slightly higher cost but that is not always the case. And yes I do sell poly bushes so I will be biased. BTW even nylon will do for the top wishbone bush and I don't make them. |
|
Oct 29th, 2009, 10:01 | #16 |
Master Member
Last Online: Jun 3rd, 2021 16:03
Join Date: Dec 2002
Location: London
|
The first thing I have done in any Amazon I've owned is to replace the seatbelts with inertia-reel, with nice classic webbing and keeping the original hardware. Quickfit do a nice job. The first time I had to take the belt off to open the passenger door was enough to prompt me to do this.
A rear LED brake light gives me peace of mind that lorries can see me braking just that bit earlier, so that's one of my good ones. Front IPD rollbar gives lurch-less cornering but seems to be stiffened up the whole ride, so good and bad on that one. I would LOVE to get my hands on an Amazon under-bonnet sound-deadening kit. Somebody please make one... When I'm cornering a mountain road in the dark and find I haven't got enough feet to accelerate, change gear AND hit the dip-switch I think, must get a column dipper conversion. Also when it seizes up, again! I like my handbrake red warning light. I have no idea why. I can't really justify it as it sits there glowing at me with the handbrake on, but I like it anyway. Now all I want is a little sensor that goes "ding-ding" when you open the door, just like in Fargo, and this will make my day (just kidding on that one). Tom |
Oct 29th, 2009, 10:17 | #17 |
Master Member
Last Online: Jan 30th, 2019 22:56
Join Date: Nov 2004
Location: Heathfield, East Sussex
|
Upgrading of rear light lenses with substitution of `blinkers` with led`s as here:
http://www.volvoforums.org.uk/showthread.php?t=77143 so much brighter and reassuring that I can be seen |
Oct 29th, 2009, 10:19 | #18 | |
Premier Member
Last Online: Apr 17th, 2024 12:54
Join Date: Jul 2008
Location: Co. Cork, Ireland.
|
Quote:
http://www.woolies-trim.co.uk/c-127-hardura.aspx The second in the list can be used for under bonnet and would look ok I think. I might give it a try but would be interested to know if anyone else has done anything similar. I agree about the headlight switch. I have a stalk one so I am alright, but foot ones are only good for automatic cars in my opinion. My car has a handbrake light, I thought these were standard? Hugh.
__________________
1970 Volvo Amazon 131 with a B20A and an M40. |
|
Oct 29th, 2009, 18:57 | #20 |
Shed Member
Last Online: Feb 5th, 2023 20:07
Join Date: Mar 2008
Location: Chorley
|
My most recent mod on my B18 Amazon is a single SU HS6 carb to replace the single Stromberg CD175. Also fitted a K&N filter at the same time. A home grown conversion using a NOS carb off Ebay.
I had previously fitted a Simons Sports exhaust and now the car goes reasonably well for a single carb job. It certainly responds much better from idle and accelerating from standstill. Other improvements:-Alternator, push button start, single wipe conversion, uprated springs and dampers. In terms of wheels, the car has 70s period Cobra Supaslots with 185/70R14 tyres. They look quite chunky because of the high aspect ratio but they certainly draw lots of attention to the car. Definitely needs an overdrive though. Please PM if you know of one available! |
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|