|
Information |
|
XC90 Aero Profile Load Carrier Bar InstructionsViews : 7592 Replies : 15Users Viewing This Thread : |
|
Thread Tools | Display Modes |
|
Apr 15th, 2012, 20:08 | #1 |
New Member
Last Online: Apr 14th, 2013 22:34
Join Date: Apr 2012
Location: Chester
|
XC90 Aero Profile Load Carrier Bar Instructions
Hello everyone,
I have recently acquired a set of original Volvo aero bar load carriers for my 2010 XC90 but, alas, they do not have the fitting instructions included. I know that it probably isn't quantum physics but I would like to get it right rather than drop the roof box on the motorway somewhere. Would any kind soul have a set of these instructions that they might be able to scan and pm or post here perhaps? I live in hope and thanks in advance. Last edited by G1zmo; Apr 15th, 2012 at 20:10. |
Apr 22nd, 2012, 10:43 | #2 |
Premier Member
Last Online: Yesterday 07:29
Join Date: Jul 2007
Location: Nottingham
|
Gizmo,
I note that no-one has replied yet. I don't have written instructions either since I bought my Aero bars from ebay some time ago. Do you have the funny-shaped tool with your bars? This is a form of torque wrench, supposedly to stop you over tightening the bars. If not, so long as you have a star-shaped allen-key type tool then you will have to tighten as much as you feel is necessary, just as every other type of roof rack is fitted. The Aero bars have a limited spring at each end - they can be compressed a little, like a Bullworker (Exercise equipment from the 80s I recall). Open the plastic cover by twisting the circular plastic plug. Then you open up the jaws on each end using the supplied tool, or another which fits properly. Standing on one side of the car, push the aero bar against the roof rail on the far side, so that it goes into the "jaws" of the bar. Push the jaws on this end forward, slip over the rail on this side, and allow it to spring back with the rail inside the jaws. Hey presto - fitted! Tighten, and refit the plastic cover with the fiddly circular stud. I have mine fitted to a roof box, which two of us can just about lift onto the roof. I put blankets on the roof first as scratch protection "just in case". I get my Wife to lower her side just inside the rails, and then I push from my side so the jaws push onto those rails, and then I clamp them onto my side. A bit long-winded I know, but I hope it helps. |
The Following User Says Thank You to AB-UK For This Useful Post: |
Apr 23rd, 2012, 17:00 | #3 |
New Member
Last Online: Apr 14th, 2013 22:34
Join Date: Apr 2012
Location: Chester
|
XC90 Aero Profile Load Carrier Bar Instructions
AB-UK,
Many thanks for the reply. Unfortunately, I too recall the 1980's fitness tool that was the Bullworker! I do have the unusual little tool that accompanies the roof bars. It seems to be a mini plastic torque wrench. I presume the needle must be turned until it sits between the two marker posts giving approximately the correct tightness. Good tip with the blanket as I intend to use the bars to hold a roof box also. Thanks again. |
Oct 1st, 2012, 23:45 | #4 |
Older than Junior Member
Last Online: Oct 12th, 2014 09:28
Join Date: Aug 2009
Location: Twon/City
|
Not sure if you still need these or not but ......
__________________
2008 XC90 D5 Executive, Sandstone Beige Leather, Active Bi-Xenons, Electric Sun Roof, Roof rails, Climate Control, Twin electric front heated seats, Volvo DTi, Full integrated phone, Westfalia Tow Bar.... |
Dec 21st, 2012, 18:46 | #5 |
New Member
Last Online: Dec 21st, 2012 18:49
Join Date: Dec 2012
Location: exeter
|
Thats great having the instructions many thanks for that also, i have just bought some off ebay too ! However i do not understand the torque wrench the plastic flange piece is fixed to the allen key so how do i read the torque ?? sorry if i appear a tad dumb
thanks |
Apr 14th, 2013, 17:52 | #6 |
VOC Member
Last Online: May 28th, 2020 23:57
Join Date: Jun 2012
Location: Wolverhampton
|
I'm unable to download the Coconuts Roof Bar document for some reason. Can everyone else download it ok?
|
Sep 30th, 2014, 21:01 | #7 |
Older than Junior Member
Last Online: Oct 12th, 2014 09:28
Join Date: Aug 2009
Location: Twon/City
|
Roof Rails & Roof Bars User Instructions
Hi everyone,
Not sure why my original link no longer works, but User instructions for these are now available on the Volvo web site : Volvocars.com : / Accessories User Guides Scroll down the list to "Load Carrier, Rails"
__________________
2008 XC90 D5 Executive, Sandstone Beige Leather, Active Bi-Xenons, Electric Sun Roof, Roof rails, Climate Control, Twin electric front heated seats, Volvo DTi, Full integrated phone, Westfalia Tow Bar.... |
Mar 8th, 2018, 16:13 | #8 |
Junior Member
Last Online: Jun 8th, 2018 19:42
Join Date: Aug 2015
Location: Dorset
|
I have just bought a set of what appear to be genuine volvo aerowing roof bars
& one is bigger than the other ? Cant seem to make them fit, any ideas ? |
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|