|
C30 / S40 & V50 '04-'12 / C70 '06-'13 General Forum for the P1-platform C30 / S40 / V50 / C70 models |
Information |
|
2007 C70 T5 door mirror removalViews : 997 Replies : 3Users Viewing This Thread : |
|
Thread Tools | Display Modes |
Aug 5th, 2018, 16:27 | #1 |
caldermeister
Last Online: Jun 30th, 2019 14:32
Join Date: Aug 2018
Location: Edinburgh
|
2007 C70 T5 door mirror removal
Hi everyone,
Can someone please enlighten me how to remove the door mirror assembly? Thanks in advance. Andy |
Aug 5th, 2018, 22:10 | #2 |
Senior Member
Last Online: Mar 31st, 2021 00:19
Join Date: Dec 2016
Location: Suburban Philly
|
Just the glass? Angle it fully in and down and pry off from the motor mount.
Whole assembly involves removing the door panel to disconnect the wiring harnesses... put the window down then disconnect the battery and wait five minutes to avoid SRS errors or worse from the curtain airbag. Pry off the aluminum/wood trim panel on the door handle, the small plastic panel top back of the door, the IC inflatable curtain plastic panel and the panel at the bottom of the handgrip you pull the door closed with. That will reveal a total of five T25 screws that need to be removed. Then you can pry off the door panel. It’s quite heavy. You need to disconnected the air bag and door module wires to remove the panel out of the way at that point. You can then disconnect the two plugs that connect to the mirror wiring and undo the clips holding the wires in place. There’s a couple of bolts one above the other toward the rear of the triangle that need to be removed. Then in the front of the door near the top there are two rubber covers about an inch in diameter. Pry them off to reveal the two long bolts running lengthwise of the car that hold the mirror assembly in place... at that point the mirror assembly can be pulled up and out of the door, after freeing it from the weatherstripping. Hope that helps. |
The Following 2 Users Say Thank You to Sysyphus For This Useful Post: |
Aug 5th, 2018, 23:21 | #3 |
Member
|
These videos will likely help:
https://www.youtube.com/watch?v=MZeeGL1F08I and https://www.youtube.com/watch?v=ZlOmEGfRcqQ
__________________
Present: 2009 Volvo V50 1.6D DRIVe SE Past: 2004 Volvo S40 T5 SE |
Aug 6th, 2018, 09:52 | #4 |
caldermeister
Last Online: Jun 30th, 2019 14:32
Join Date: Aug 2018
Location: Edinburgh
|
I had everything done the same yesterday just never knew to pull the mirror up ! Doh!, thanks a lot. do you know if i can get new pulleys for window runners anywhere?
Cheers Andy |
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
Thread Tools | |
Display Modes | |
|
|