Common S60 Problems - Solutions Only
Here's a few common problems that come up on the forum, with solutions where possible. Feel free to add your own or correct me, too! Some may apply to the V70 as well...
Note: please don't use this thread to ask about problems - only use it to post solutions you've found. Door lock popping up - usually on early cars (up to 02?) Currently requires replacement lock although Volvo may pay 50% up to 4 years old. Power steering fluid loss - either failure of the hose or seam going on the tank. Known problem by Volvo Air con cutting in after about an hour when parked - normal, it's the system drying itself out. "Clunk" when moving off - on cars up to MY04 - it's the ABS system test. Doesn't happen on MY05 and later Turning Circle very poor - it's an S60. Live with it! to be continued.... |
Haynes Manual for S60 - there isn't one. There is one for the "Mk 2" V70, so that may help if the problem is at the front of the car....
****update....The S60 Haynes Manual is now available to order - Book No. 4793.**** |
Thanks to "oilburner" for this one:
"One shot" function causing window to get part way up and then "bounce" down: Try performing a reset of the UEM (Upper Electronic Module), this controls the door locks and window operation: - Close all of the doors and bonnet. - Key in position II engine not running. - Hold both the driver window and passenger window switches in the driver door panel in the closed or up position for 5 to 8 seconds after the windows are closed. - Release buttons. - Remove the ignition key. - Operated the remote twice. lock/unlock lock/unlock. This will reset the UEM brain. This can correct faulty operation of the sunroof and/or erratic door lock function. Worked for mine. I had the same problem after the electric mirror switch was replaced. EDIT: This may or may not wipe out the settings for the auto-lock, I do not know for certain as mine doesn't do it! You could also try locking and unlocking the car via the drivers door lock, this might do the same thing - but may also loose your settings, unless the auto-lock is controlled via another of the car's computers - it could be, I don't know for sure. |
Lights not flashing when locking car with remote - check all doors, bonnet & boot are fully shut; often opening boot/bonnet & slamming shut fixes this!
|
Applies to R model only but sometimes standard S60s
Axle ping /clunk Volvo tech bulletin issued as discussed in: http://forums.swedespeed.com/zerothr...=101873&page=1 http://forums.swedespeed.com/zerothread?id=60005 http://forums.swedespeed.com/zerothread?id=21132 |
The engine starter is totally dead when the ignition key is turned on.
Solution; Either have someone hold the key operated whilst you tap the starter motor body with a relatively heavy bar (or similar) Or Tap the starter motor body with a relatively heavy bar and then retry starting the car. Obviously replacing the starter motor would be the best solution but as this problems tends to happen randomly and only on rare occasions, the above solutions have kept me going for over 5 years at no expense. |
Quote:
|
Quote:
Tony |
[QUOTE=Graeme Catnach;265959]Here's a few common problems that come up on the forum, with solutions where possible. Feel free to add your own or correct me, too! Some may apply to the V70 as well...
Power steering fluid loss - either failure of the hose or seam going on the tank. Known problem by Volvo Thanks for the info Graeme. I recently had a leak from the power steering reservoir / drain pipe of my S60 D5. (I got through about a litre of fluid in a month). After removing and cleaning the reservoir and pipe, I couldn't see any damage anywhere so just refitted, but tightened the hose-clip that bit extra. It's been fine for a week now. So I think it's worth checking before buying the parts. Cheers Paul |
Handbrake shoe linings separating.
They have just gone on my four and a half year old S60 D5. For some time now I have noticed a delayed release from the handbrake. Last weekend I went to take the car out the garage to wash it, it had been sitting in the garage for a week in gear, handbrake off. The car would not move off as normal, right rear wheel locked solid. Eventually released after dragging for six feet out of the garage. Contacted Volvo and told not to drive at speed as the now loose lining(s) could catch in the stub axle causing over one thousand pounds damage. Car booked into local dealer for new set of rear discs, pads and shoes. Cost quoted at just under £400 before VOC discount. Covered in this thread among others: http://www.volvoforums.org.uk/showthread.php?t=64804 |
All times are GMT +1. The time now is 07:38. |
Powered by vBulletin
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.